GET A QUOTE

Waste Heat Recovery Boiler For Ships

Organic Rankine cycle systems for waste heat recovery in

2015-12-9 · Keywords: Waste heat recovery, Organic Rankine cycle, Internal combustion engine, Marine 1. INTRODUCTION The new impositions and restrictions imposed to ships emissions and also the global tendency of developing greener ships has pushed and motivated the research towards the improvement of the efficiency of ships.

Get a Quote

Waste heat recovery - Alfa Laval

2016-10-25 · waste heat recovery is to try to recover maximum amounts of heat in the plant and to reuse it as much as possible, instead of just releasing it into the air or a nearby river. Figure 1.2 Energy flow without waste heat recovery Figure 1.3 Energy flow with waste heat recovery Fuel Heat generation (boilers, heaters) Process Cooling Surroundings

Get a Quote

China boiler for power plant, heat recovery boiler

2019-1-22 · China Boiler for Power Plants. The main products include: utility boilers in steam capacities upto 670t/h and in types of pulverized coal-fired, circulating fluidized bed, cyclone-fired, bubbling-bed, chain-grate stoker, gas/oil-fired etc., industrial boilers in capacities from 6.5t/h to 20t/h, heat recovery boilers used in petro-chemical, steel and cement industries, alkali recovery black

Get a Quote

Soot Deposits and Fires in Exhaust gas Boilers

2019-4-13 · standard engines without waste heat recovery system, is about 240 270°C, but may be lower for derated engines. The name "exhaust gas economiser" is often used for an exhaust gas boiler which is not able to operate separately, i.e. without its own steam drum. In this paper, the name "exhaust gas boiler"

Get a Quote

Waste heat recovery: technologically and economically

2016-10-4 · 2. Waste heat recovery, the next challenge of energy-intensive industries 3. Energy conversion technologies : Challenges amp; solutions by industrial sector p.14 1. Cement p.15 2. Aluminium p.21 3. Glass p.27 4. Steel p.32 5. Recommendations for making an investment in waste heat recovery p.40 : Appendices p.42 Key references p.43 Glossary p.44

Get a Quote

Soot Deposits and Fires in Exhaust gas Boilers

2019-4-13 · standard engines without waste heat recovery system, is about 240 270°C, but may be lower for derated engines. The name "exhaust gas economiser" is often used for an exhaust gas boiler which is not able to operate separately, i.e. without its own steam drum. In this paper, the name "exhaust gas boiler"

Get a Quote

Sustainable energy design of cruise ships through

Waste heat recovery optimization of cruise ships equipped by LNG engines. • Novel energy saving technologies and strategies for cruise ships. • Fuel savings (1.9 kt/y), avoided CO 2 (4.51 kt/y), and paybacks (lower than 5 years).

Get a Quote

Steam Generators and Waste Heat Boilers: For Process

V. Ganapathy is a consultant on steam generators and waste heat boilers based in Chennai, India. He has over 42 years of experience in the engineering of steam generators and waste heat boilers with emphasis on thermal design, performance, and heat transfer aspects. He also develops custom software on boiler design and performance.

Get a Quote

Seaspan Ship Management opts for Alfa Laval

Hong Kong-based containership manager and owner Seaspan Ship Management has opted for low-sulphur fuels for its ships as part of its strategy to meet the IMO 2020 sulphur cap. However, like most container vessels, the Seaspan-owned ships have only a single oil-fired boiler and a waste heat recovery boiler

Get a Quote

Energy and exergy analysis of an exhaust energy recovery

Exhaust energy of a diesel engine was recovered with organic Rankine cycle for improving fuel economy.R245fa was used as the working fluid in the Rankine cycle.Thermal efficiency of Rankine cycle was calculated under different evaporation pressures.Exergy

Get a Quote

New Mærsk Triple-E ships worlds largest and most

2011-2-21 · For the Triple-E, the effect of the waste heat recovery system is a reduction in the engine's fuel consumption and CO 2 emissions by approximately 9%. When exhaust gas leaves the engine, it has a very high heat potential. Utilizing this potential in an exhaust gas boiler, it is possible to generate steam.

Get a Quote

(PDF) Waste Heat Recovery Technologies and

heat boiler, a waste heat recovery system was produced that can re- cover sensible heat from hot air emitted by the cooling process of sinter coolers located downstream of sinter machines.

Get a Quote

What is Waste Heat Recovery? (with picture)

The development of waste heat recovery systems for cars and ships is already under way. What is known as a thermoelectric generator is being produced for cars. This is a unit which can convert the car's waste heat into electricity, supplying all the electricity it needs and improving fuel efficiency at the same time.

Get a Quote

waste heat recovery boiler from power generator

Waste Heat Recovery Boiler - Thermax. Waste heat Recovery Boiler Thermax manufactures hot water boilers in the range of 50,000 to 90,00,000 kcal per hour. The hot water boilers are designed to operate on various types of fuels such as heavy oil, light oil, gas, duel fuel, coal, husk and other agro waste fuels.

Get a Quote

Boiler Stack Gas Heat Recovery - apps.dtic.mil

2011-5-14 · Boiler Stack Gas Heat Recovery ABSTRACT This report is a detailed study of various heat recovery schemes for Navy shore facilities to utilize otherwise lost stack heat. The waste heat can be used alternatively to improve the boiler efficiency through feedwater and/or combustion-air preheating, or to lighten the boiler load through

Get a Quote

Efficiency in boilers and beyond - Alfa Laval

2017-3-28 · waste heat recovery systems can even be constructed to provide a boost in propulsion. Partnered for guaranteed savings The effectiveness of Alfa Laval waste heat recovery systems derives not only from our own boiler technologies, but also from our ability to work with others. Our systems are developed in deep cooperation with other suppliers,

Get a Quote

Seaspan Ship Management opts for Alfa Laval

Hong Kong-based containership manager and owner Seaspan Ship Management has opted for low-sulphur fuels for its ships as part of its strategy to meet the IMO 2020 sulphur cap. However, like most container vessels, the Seaspan-owned ships have only a single oil-fired boiler and a waste heat recovery boiler

Get a Quote

Organic Rankine cycle systems for waste heat recovery in

2015-12-9 · Keywords: Waste heat recovery, Organic Rankine cycle, Internal combustion engine, Marine 1. INTRODUCTION The new impositions and restrictions imposed to ships emissions and also the global tendency of developing greener ships has pushed and motivated the research towards the improvement of the efficiency of ships.

Get a Quote

Technical and economic feasibility of organic Rankine

Moreover, the results suggest that the cost-effectiveness of the organic Rankine cycle units is highly affected by fuel price and the waste heat recovery boiler design constraints. AB - The International Maritime Organization recently revised the regulations concerning nitrogen and sulphur oxides emissions from commercial ships.

Get a Quote

Waste heat recovery - Alfa Laval

2016-10-25 · waste heat recovery is to try to recover maximum amounts of heat in the plant and to reuse it as much as possible, instead of just releasing it into the air or a nearby river. Figure 1.2 Energy flow without waste heat recovery Figure 1.3 Energy flow with waste heat recovery Fuel Heat generation (boilers, heaters) Process Cooling Surroundings

Get a Quote